Is It Okay To Mix Old Gas With New Gas Patio Heaters – What Your Patio Heater Manual Doesn’t Tell You

You are searching about Is It Okay To Mix Old Gas With New Gas, today we will share with you article about Is It Okay To Mix Old Gas With New Gas was compiled and edited by our team from many sources on the internet. Hope this article on the topic Is It Okay To Mix Old Gas With New Gas is useful to you.

Patio Heaters – What Your Patio Heater Manual Doesn’t Tell You

Patio heating, like any other equipment, needs periodic maintenance. When you check your manual, you will probably have very good instructions on how to assemble and use your patio heater. There may also be some helpful troubleshooting information if your patio heater isn’t working properly. But there is something that the manufacturer does not bother to let you know.

The warm seasons are winding down and you pull your patio heater out of storage, ready to warm those brisk mornings and cooler nights. You turn on the natural gas supply or make sure you have a full tank of propane. Friends and family look forward to standing by the patio heater, so you go to turn it on. Using the external heater before, you know turn the key to pilot and press the ignition button…click and it won’t turn on. Ok, try again, click and it won’t turn on again. Your guests continue to wait patiently, but slowly begin to move in and out of the cooler. You check the gas supply again and try the ignition process a few more times, but decide to move the party inside.

The next day you check the instructions and troubleshooting guide, but you still can’t get the patio heater to turn on, and you think you might need a new outdoor heater to move the pool outside once again. However, if you knew a few maintenance tips, you could save yourself the cost of a new patio heater and be the life of the party again.

What most patio heater instructions won’t tell you is that a covered or stored heater is a favorite home for spiders and other small creatures. The cool, dark and confined space creates a perfect nesting place for our eight-legged friends. Debris, cobwebs, and cobwebs built up while your patio heater is not in use clog up important functional parts, causing it to not function properly or at all. Unfortunately, without disassembling some key parts, you will never be able to see the problem created by the mesh, debris, or nest. If your patio heater is more than a year old, it’s most likely out of warranty and the manufacturer won’t offer much help.

So what do you do now to get your outdoor patio heater back up and running? Almost all natural gas or propane patio heaters contain the same components of a control valve, a pilot, a thermocouple and a main burner. Getting to and cleaning these components is essential to getting the outdoor heater working again.

Cleaning the interior of your patio heater:

Note: Always make sure the patio heater is cold, with any gas supply turned off.

1. Remove the emitter cover or reflector and screen. The parts are usually attached to the main burner housing with four screws. Once removed, you will have access to the main igniter, pilot and thermocouple.

2. Remove the main burner, which is usually attached to a bracket with anywhere from two to four screws. Once the main burner is removed, you will have access to the main burner hole. The nozzle is a small brass fitting with a small hole, measured on the gauge. This small opening can be blocked or obstructed by debris, the nest or web left by the spider. Since very little or no gas can pass through the barrier, the external heater will not create a flame or will have a very yellow sooty flame.

3. Remove this hole for cleaning with a wrench or socket. To clean, use compressed air or a needle to remove any obstruction.

4. Check the pilot for any other obstructions. Occasionally, the pilot hole, like the main burn hole, will have deposits left over from spiders. This brass fitting will have an even smaller hole than the main burner hole. Removing the pilot nozzle can be tricky, as different manufacturers will secure the pilot in different ways. Most pilots, however, will be connected to a bracket that holds the pilot and thermocouple. Loosen this bracket so that you have free access to the pilot. The pilot opening will be directly on top of the small copper tube and just below the pilot. Remove the pilot and then remove the pilot hole. Clean the pilot hole in the same way as the main burner hole with compressed air or a needle.

5. In the main burner, there should be two openings near the bottom of the burner, these are called venturis. Make sure the opening is unobstructed so that the air can mix properly with the gas.

6. With all patio heater parts cleaned, reassemble all parts in reverse order from above, but DO NOT reattach the cover (reflector).

7. Reconnect and turn on the gas supply. Following your operating manual, turn the patio heater on only in the pilot position. While holding the control switch in the pilot position, check and see that the pilot is lit, with the flame touching the tip of the thermocouple. After checking this, release the control switch (about 30 – 60 seconds) and the pilot should remain on. If not, wait for the heater to cool and follow the instructions above for cleaning the pilot nozzle. Reassemble and turn the pilot back on.

8. Once the pilot remains lit, turn the control knob to the high position. If the main burner hole is properly cleaned, you should see a 4 – 6 inch blue flame with an orange-yellow tip. If the flame is almost all yellow, then the obstructions in the combustion venturi have not been properly cleaned. Venturis allow air to mix with gas to burn cleanly. If air is not mixed with the gas, a yellow, dirty flame is created.

9. With the pilot and main burner now in perfect working order, wait for the patio heater to cool and then refit the emitter screen and hood back to the housing bracket, using the same screws provided

10. Fire up your patio heater and your back to work and ready to have another great party, gathering or outdoor dining experience.

Please note that with a natural gas or propane patio heater, if you are uncomfortable with gas appliances, contact a qualified gas technician.

Want to know more about patio heaters, visit PatioHeatingUSA.com.

Video about Is It Okay To Mix Old Gas With New Gas

You can see more content about Is It Okay To Mix Old Gas With New Gas on our youtube channel: Click Here

Question about Is It Okay To Mix Old Gas With New Gas

If you have any questions about Is It Okay To Mix Old Gas With New Gas, please let us know, all your questions or suggestions will help us improve in the following articles!

The article Is It Okay To Mix Old Gas With New Gas was compiled by me and my team from many sources. If you find the article Is It Okay To Mix Old Gas With New Gas helpful to you, please support the team Like or Share!

Rate Articles Is It Okay To Mix Old Gas With New Gas

Rate: 4-5 stars
Ratings: 5987
Views: 32886532

Search keywords Is It Okay To Mix Old Gas With New Gas

Is It Okay To Mix Old Gas With New Gas
way Is It Okay To Mix Old Gas With New Gas
tutorial Is It Okay To Mix Old Gas With New Gas
Is It Okay To Mix Old Gas With New Gas free
#Patio #Heaters #Patio #Heater #Manual #Doesnt

Source: https://ezinearticles.com/?Patio-Heaters—What-Your-Patio-Heater-Manual-Doesnt-Tell-You&id=6609570

Related Posts

default-image-feature

Weight For 63 Year Old Woman That Is 5 2 What Are the Risks of Being Diagnosed With Ovarian Cancer?

You are searching about Weight For 63 Year Old Woman That Is 5 2, today we will share with you article about Weight For 63 Year Old…

default-image-feature

Weight For 12 Year Old Girl That Is 5 2 Kettlebell Training – An Interview With Steve Cotter

You are searching about Weight For 12 Year Old Girl That Is 5 2, today we will share with you article about Weight For 12 Year Old…

default-image-feature

How Much Tylenol Can You Give A 5 Month Old Fish Oil for Natural Pain Relief

You are searching about How Much Tylenol Can You Give A 5 Month Old, today we will share with you article about How Much Tylenol Can You…

default-image-feature

Weight For 12 Year Old Boy Who Is 5 5 Polynesian Weight Loss – 12 Diet Secrets to Accelerate Your Weight Loss

You are searching about Weight For 12 Year Old Boy Who Is 5 5, today we will share with you article about Weight For 12 Year Old…

default-image-feature

How Many Ounces Should A 5 Month Old Be Eating "Hullababloo" (A Shannon O’Day Short Murder Story)

You are searching about How Many Ounces Should A 5 Month Old Be Eating, today we will share with you article about How Many Ounces Should A…

default-image-feature

Is It Ok To Put New Siding Over Old Siding Log Homes During Winter

You are searching about Is It Ok To Put New Siding Over Old Siding, today we will share with you article about Is It Ok To Put…